Ford Repair & Service Milwaukie Oregon

2009 Ford Escape
Mileage
159,884
Service Date
9/27/2024
Services Performed
PERFORM BASIC SAFETY INSPECTION : VISUAL ONLY; LIGHTS, FILTERS CHECK FOR OIL CHANGE ETC
INSPECT AND ADVISE: DIED WHILE DRIVING, BAT LIGHT AND OIL LIGHT FLASHED AS SHUTTING OFF. STARTED BACK UP AND CONTINUED DRIVING NO PROBLEM. PLEASE CHECK AND ADVISE
NO DRIVABILITY ISSUES PRESENT. SCANNED SYTEMS, PCM CODE P0455 EVAP SYSTEM LARGE LEAK DETECTE. MAY OR MAY NOT BE RELATED TO DIE CONDITION (A FAILED PURGE VALVE MY CAUSE A DIE AT IDLE ONLY). NEED DIAGNOTICS FOR AN INTERMITTENT ISSUE. DRIVE CYCLED AND MONITORED DATA, NO EVIDENCE OR ABNORMAL DATA NOTED. MOST COMMON STALL ISSUES PER IDENTIFIX 1. PCM WITH COILS (APPEAR MARGINAL( PLUGS WORN). 2. EVAP PURGE VALVE (DOES NOT APPEARS TO FLOW UNCOMMANDED), 3. MAF SENSOR (F..T.'S WITHIN RANGE) 4. FUEL PUMP CONTROLS UNIT, OR FUEL PUMP (AMP DRAW IS 6.7 CURRENTLY & ON HIGHER SIDE. CLEANED T.B. AND MAF AS P.M. & PRECAUTION. CUSTOMER CAN MONITOR OR WE CAN KEEP AND CONTINUE TESTING WITH LEVEL 2 DIAG.
ALYSSA R. gave our service a 5 star review on 9/29/2024
2006 Ford Mustang
Mileage
127,296
Service Date
9/20/2024
Services Performed
PERFORM DIGITAL VEHICLE INSPECTION. PROVIDE CUSTOMER WITH EMAIL REPORT AND SERVICE WRITER CONSULTATION REGARDING INSPECTION.
TECH DROVE AND FELT CUSTOMERS CONCERN. RECOMMEND DIAGNOSTIC TIME
DIAGNOSTICS: BUCK AND SURGE AT CERTAIN THROTTLE AND LOAD CONDITIONS. SCANNED AND NO PCM CODES. WHILE MONITORING SCAN DATA NOTED SYMPTOM IS NEAR 10% THROTTLE OPENING AND EGR FLOW IS 30-50%. DISABLED EGR VALVE AND CONFIRMED NO SURGE ISSUE. EGR FLOW IS EXCESSIVE DUE TO A FAILED EGR SYSTEM MODULE. ALSO NOTED A DIRTY THOTTLE BODY & MAF SENSOR, IMPROPERLY GAPPED SPARK PLUGS @ .035" SPEC IS .052-056", IGNITION WIRES RESTING ON HOT EGR TUBE (WIRES ARE DAMAGED). RECOMMEND ALL ABOVE REPAIRS AND RETEST.
JAVIER G. gave our service a 5 star review on 9/20/2024
2005 Ford Ranger
Mileage
134,371
Service Date
6/14/2024
Services Performed
PERFORM DIGITAL VEHICLE INSPECTION. PROVIDE CUSTOMER WITH EMAIL REPORT AND SERVICE WRITER CONSULTATION REGARDING INSPECTION.
TECHNICIAN FOUND P1120 CODE IN SYSTEM. CODE IS RELATING TO THE THROTTLE POSITION SENSOR. DIAGNOSTIC TIME REQUIRED TO DETERMINE CAUSE OF PROBLEM.
HOOKED UP SCANNER AND FOUND CODE P1120 THROTTLE POSITION SENSOR OUT OF RANGE LOW (TOO LOW) WATCHED THROTTLE POSITION DATA WHILE SWEEPING THROTTLE AND FOUND NO VOLTAGE GLITCHES OR DROP OUT FOUND, TEST DROVE AND SAME. CLOSED THROTTLE VOLTAGE IS .9V WIDE OPEN THROTTLE 4.58V. FOR CODE TO SET VOLTAGE HAS TO DROP BELOW .49V PERFORMED HARNESS TUG AND WIGGLED TEST WHILE WATCHING TPS DATA, FOUND VOLTAGE REMAINED NORMAL. BASED ON REFERENCE DIAGNOSTIC INFORMATION TPS IS A COMMON FAILURE. SENSOR APPEARS TO BE NON OE, RECOMMEND REPLACING WITH MOTORCRAFT PART AND REPLACE CONNECTOR THEN RETEST. SIGNS OF RECENT UNDER HOOD DETAIL, MOISTURE COULD HAVE GOT INTO SENSOR AND CAUSED CORROSION INSIDE SENSOR.
REAR AXLE SHAFT SEAL – Remove & Replace – Both // Includes: Replace Axle Bearings
REPLACE BRAKE SHOES UNDER WARRANTY : ORIGINAL DONE 2/2024 @ 134062 MILES, RO #55659
PERFORM BG REAR DIFFERENTIAL FLUID EXCHANGE SERVICE
THROTTLE POSITION SENSOR – Remove & Replace – 2.3L Eng – [Includes: Component test.]
BENITA S. gave our service a 5 star review on 6/23/2024
2020 Ford Transit-250
Mileage
143,287
Service Date
5/28/2024
Services Performed
INCLUDES : TEST DRIVE VEHICLE – SCAN ALL MODULES FOR PENDING / ACTIVE CODES – PERFORM THOROUGH INSPECTION INSIDE, UNDERNEATH AND UNDERHOOD OF VEHICLE – ADVISE OF NEEDS AND GENERAL VEHICLE CONDITION.
KIRSTEN C. gave our service a 5 star review on 5/30/2024
2009 Ford Escape
Mileage
157,069
Service Date
5/16/2024
Services Performed
UPON ARRIVAL, TECHNICIAN VERIFIED HVAC MODE CONTROLS INOP. ADDITIONAL TIME REQUIRED TO PINPOINT THE CAUSE OF THE PROBLEM.
DISC ROTOR – Remove & Replace – Front,Both – [Includes: Repack Wheel Bearings (where applicable) and replace Pads (if necessary). DOES NOT include refinishing.]
BG BRAKE FLUID EXCHANGE SERVICE.
INSPECTED HVAC CONTROLS. FOUND THE INDICATOR LIGHT MOVING WITH MODES WITH NO RESPONSE FROM HVAC UNIT. CONNECTED SCANNER AND VERIFIED CONTROL MODULE IS RECEIVING COMMANDS FROM UNIT. COMMANDED EACH OF THE ACTUATORS, THE MODE DOOR ACTUATOR IS STUCK AND HAS DAMAGED GEARS INSIDE. NEEDS ACTUATOR REPLACED AND PROGRAMMED.
REMOVE AND REPLACE – BLEND DOOR ACTUATOR
ALYSSA R. gave our service a 5 star review on 5/27/2024
2004 Ford Thunderbird
Mileage
113,970
Service Date
2/27/2024
Services Performed
PERFORM BASIC SAFETY INSPECTION : VISUAL ONLY
INSPECT AND ADVISE: LEAKING CLEAR FLUID ON THE GARAGE FLOOR (NOT WATER) STEERING FEELS DIFFERENT
REPLACED THERMOSTAT UNDER WARRANTY : ORIGINAL DONE 7/2022 @ 111316 MILES, RO #51307 PRESSURE TESTED AFTER REPAIRS, NO LEAKS
SHARON S. gave our service a 5 star review on 2/28/2024
2006 Ford Mustang
Mileage
83,872
Service Date
1/19/2024
Services Performed
PERFORM DIGITAL VEHICLE INSPECTION. PROVIDE CUSTOMER WITH EMAIL REPORT AND SERVICE WRITER CONSULTATION REGARDING INSPECTION.
CHANGE MOTOR OIL AND FILTER. CHECK ALL FLUIDS AND LIGHTS. LUBE CHASSIS IF APPLICABLE. CHECK TIRE PRESSURE.
COURTNEY S. gave our service a 5 star review on 1/19/2024
2007 Ford Escape
Mileage
230,297
Service Date
7/25/2023
Services Performed
PERFORM DIGITAL VEHICLE INSPECTION. PROVIDE CUSTOMER WITH EMAIL REPORT AND SERVICE WRITER CONSULTATION REGARDING INSPECTION.
FOUND DRIVER SIDE SUNROOF DRAIN PLUGGED, TOOK A GOOD FORCE OF AIR TO UNPLUG IT, NOW DRAIN DRAINS.
NEED TO DISASSEMBLE AT DOOR AND INSPECT ALL OF THE ELECTRICAL INSIDE
FOUND DOOR AJAR LIGHT ON AT ALL TIMES, USED SCANNER TO LOOK AT DOOR AJAR DATA, FOUND PASSENGER DOOR AJAR SWITCH READING AJAR, LUBRICATION AND TAPPING ON LATCH DID NOT CHANGE, WILL REQUIRE DOOR PANEL REMOVAL AND INSPECT/TEST SWITCH AND WIRING, MOST LIKELY NEED TO REPLACE SWITCH. POSSIBLY BROKEN WIRE IN DOOR HARNESS. REMOVED DOOR PANEL, DISCONNECTED LATCH CONNECTER, USE POWER PROBE AND VERIFIED POWER TO AJAR SWITCH, POWER PRESENT, WHEN GROUNDED AJAR LIGHT GOES OUT, VERIFIED GROUND CIRCUIT WAS GOOD. NEED TO REPLACE LATCH/SWITCH ASSEMBLY AND RECHECK.
CHANGE MOTOR OIL AND FILTER. CHECK ALL FLUIDS AND LIGHTS. LUBE CHASSIS IF APPLICABLE. CHECK TIRE PRESSURE.
REPLACE LIGHT BULB – LICENSE PLATE LIGHT BULB
RINA S. gave our service a 5 star review on 7/25/2023
2016 Ford F-550 Super Duty
Mileage
28,455
Service Date
6/22/2023
Services Performed
PERFORM DIGITAL VEHICLE INSPECTION. PROVIDE CUSTOMER WITH EMAIL REPORT AND SERVICE WRITER CONSULTATION REGARDING INSPECTION.
INSPECT AND ADVISE – CYL. 6 MISFIRE (SEE OTHER INVOICE ON CLIPBOARD)
VERIFIED MISFIRE CAN BE FELT. USED SCANNER VERIFIED CYLINDER 6 MISFIRE, CODES P0306 CYLINDER 6 MISFIRE. P0316 MISFIRE ON START UP. USED SCANNER TO PERFORM POWER BALANCE TEST CYLINDER 6, TEST RESULTS ARE CYLINDER 6 IS DOWN. USED SCANNER TO PERFORM RELATIVE COMPRESSION TEST FOR CYLINDER 6, TEST RESULTS ARE CYLINDER 6 HAS A MIN OF 10% DIFFERENCE. CAN HEAR LOW COMPRESSION CYLINDER WHILE CRANKING ENGINE. PERFORMED COMPRESSION TEST WITH MANUAL GAUAGE AND FOUND CYLINDER 6 WAS ABOUT 145PSI TESTED CYLINDER ON OPPOSITE BANK AND HAVE ABOUT 200PSI, TESTED ANOTHER CYLINDER ON THE SAME BANK AS CYLINDER 6 AND FOUND ABOUT 200PSI. RESULTS CONFIRM CYLINDER 6 HAS LOW COMPRESSION. FOUND TSB FOR ISSUES ON THE COMMERCIAL/STRIPPED CHASSIE 550S FOR CAM ROLLER FOLLOWERS. REMOVED VALVE COVER AND INSPECTED CYLINDER 6 VALVE SPRINGS. ALL LOOKS OK. PERFORMED CYLINDER LEAK DOWN TEST ON CYLINDER 6, RESULTS ARE 60% LEAK DOWN INTO CRANK CASE. PERFORMED LEAK ON ON CYLINDER NEXT TO IT AND FOUND 15% LEAK DOWN. THIS CONFIRMS CYLINDER 6 IS LOW COMPRESSION IS CAUSED FROM FAILED PISTION AND OR RINGS, WILL REQUIRE ADDITIONAL TEAR DOWM TO PINPOINT. RECOMMEND ENGINE OR RING REPLACEMENT.
JOHN B. gave our service a 5 star review on 6/22/2023
2008 Ford Econoline
Mileage
50,208
Service Date
6/6/2023
Services Performed
PERFORM DIGITAL VEHICLE INSPECTION. PROVIDE CUSTOMER WITH EMAIL REPORT AND SERVICE WRITER CONSULTATION REGARDING INSPECTION.
CHANGE MOTOR OIL AND FILTER. CHECK ALL FLUIDS AND LIGHTS. LUBE CHASSIS IF APPLICABLE. CHECK TIRE PRESSURE.
REBECCA D. gave our service a 5 star review on 6/6/2023

Ford

We Service and Repair all Ford cars